Product ID:SKL-HF/S SPOTCHECK PENETRANT
MSDS Date:05/28/1986
FSC:6850
NIIN:01-265-7233
MSDS Number: BGRXN

MAGNAFLUX CORPORATION

7300 W.LAWRENCE AVE
CHICAGO, IL 60656
US

Emergency Phone: 312-867-8000

Info Phone: 312-867-8000

Preparer: BRUCE C. GRAHAM (CHEMIST)

Cage: 37676

ILLINOIS TOOL WORKS INC MAGNAFLUX DIV

GLENVIEW, IL 60025 US

Telephone: 847-657-5300/

Cage: 37676

DISTILATES(PETROLEUM),CATALYTIC REFORMER FRACTIONATER

CAS: 68477-31-6

Fraction By Weight: >85.0%

KEROSENE

CAS: 8008-20-6

RTECS: OA5500000

Fraction By Weight: 10.0%

ACGIH TLV: 100MG/CUM

C.I. SOLVENT YELLOW 14 (SARA III)

CAS: 842-07-9

RTECS: QL4900000

Fraction By Weight: 01.0%

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: <5.0%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:MIST/SPRAY MAY CAUSE EYES/SKIN
IRRITATION
Effects of Overexposure:INHALATION:CAUSES
DIZZINESS,NAUSEA,DROWSINESS,FROM INHALATION OF SPRAY MIST;
SKIN:CAUSES IRRITATION,DISSOLVES SKIN OILS.POSSIBLE DERMATITIS ON
FREQUENT OR PROLONGED EXPOSURE; EYES:MODERATE IRRITATION BY
CONTACT OF LIQUID OR SPRAY; INGESTION:LOW TOXICITY,BUT HAZARDOUS IF
ASPIRATED INTO LUNGS BY INGESTION OR VOMITING.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.

First Aid:INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE CPR.IF
BREATHING IS DIFFICULT,GIVE OXYGEN; SKIN:WASH OFF IN FLOWING WATER
OR SHOWER.RMV CONTAMINATED CLOTHING AND WASH BEFORE RE-USE.USE
SOOTHING L OTION; EYES:FLUSH EYES W/A STEADY,GENTALFLOW OF
WATER.GET MEDICAL ASST; INGESTION:DO NOT INDUCE VOMITING.IF VOMIT
IS INHALED,IT MAY CAUSE ASPHYXIATION.GET MEDICAL ATTN
IMMEDIATELY;IN EMERGENCY CALL M

Flash Point:N/R (AEROSOL)
Lower Limits:6.0(LIQUID)
Upper Limits:1.0 (LIQ)
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.THE AEROSOL CANS MAY
BURST & EXPLODE IN HEAT OF FIRE

Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.DO
NOT SPRAY INTO FLAMES,ARCS,HOT SURFACES.

Respiratory Protection:WEAR A RESPIRATOR WITH CHEMICAL CARTRIDGE. IN
CONFINED AREAS,WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM LIMIT.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Other Protective Equipment:EITHER USE IN A SPRAY BOOTH OR NEXT TO AN
EXHAUST VENT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHES BEFORE RE-USE.
Supplemental Safety and Health
ONE PART PRODUCT; QPL-25135-15 SPECIFIED SKL-HF/S PENETRANT AS TYPE
II,METHOD C PRODUCT OF MIL-I-25135,REV "D";THIS ENTRY DESCRIBES
SKL-HF/S PENETRANT;THE QPL-25135-15 ALSO QUALIFIED OTHER PRODUCTS
SU CH AS SKL-HT;SKL-LO;SKL-LT;& SKL-WP PENETRANTS OF MAGNAFLUX CORP
FOR TYPE II,METHOD C;SEE OTHER P/N IND FOR THESE ITEMS.

HCC:V2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK RED LIQUID (BEFORE FILLING IN AEROSOL CANS).

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS &/OR CORROSIVE MATERIAL
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES.
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN.

Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS;INSURE THAT AEROSOL CANS ARE EMPTY
& DEPRESSURIZED BEFORE DISCA RDING,UNLESS WASTE TREATMENT PLANT
ACCEPTS AS IS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.